• Chambres environnementales température & humidité selon ICH

Chambres environnementales température & humidité selon ICH


Features
Temperature & Humidity Control Range
Safety Features
  • Completed photostability test alarm.
  • Built in door lock.
  • Automatic shut off after overheat alarm.
  • Low and empty water level alarm.
  • Power supply leakage breaker.
  • Over current protection.
  • Overheat protection.
  • Door open alarm.
Operating Features
  • Microprocess PID control / Auto-tuning / Calibration.
  • User friendly LCD controller.
    • Set value and present value are clearly visible together on display.
    • Operating progression visible in graph mode allow for direct data interpretation.
    • Temperature and other operating parameters recorded with use of an optional recorder. (optional)
  • Sufficient programmable control support.
     
Description TH-ICH
Programmable Pattern Capacity 10
Pattern Repeat Time 999
Max. Segments per a Pattern 100
Available Max. Segments* 10
Programmable Process Time per a Segment 0 to 99 hr 59 min
* Even though the max. segments per a pattern are 100, available total segments are up to 300 not 3000, so you need to arrange the number of segment an patterns properly.

 

  • Computer interface
    • RS-485 communication port enables connection of up to maximum 9 units. Simultaneous monitoring and operating of multiple units is an available feature. (optional)
    • Program patterns are simple to set with the use of our software.
    • Storage of program information, backup of value settings / recovery, and temperature values.
    • RS-232C port as standard offer.
Constructional Features
  • Two different sized models available to suit any users’ needs
  • Rapid humidity control is achieved by adapting the humidification tank interior to the chamber.
  • Corrosion resistance stainless steel chamber and electric polished humidification tank.
  • Air-tight door closure with perfect sealed packing.
    • Heat-resistant silicone packing completely blocks high heat leakage from the inner chamber.
  • Cable port for external probes or wires.
    • 50mm diameter cable port comes standard on the left side of the unit. Additional 50mm or 80mm diameter cable ports can be custom ordered. (optional)
  • Inner glass door with entry ports for handling samples without affecting inner chamber temperature and humidity. (optional)
  • Casters for easy mobility during installation or relocation.
Features for Stability Test ICH Guideline Q1A (R2)
  • Operating progression visible through graph mode for better data analyzation.
  • Cyclic defrost system, designed to work excellently for the long period stability test operation. (* Temperature and humidity changes may occur during automatic defrost.)
  • Maintenance of water supply are easily performed with a front water tank.
    • Water level check indicated by water level bar in the tank.
  • Water supply during operation is also available for long term test purposes.
  • Direct water system provides user great convenience when performing long-term test.(optional)
Features for Photostability Test ICH GuidelineQ1B(Option 2)
  • Built in UV and fluorescent lamps for uniformed luminescence.
  • Equipped with movable UV and VIS sensors.
  • Independent lamp controller.
    • An indicator for Total usage time of UV and fluorescent lamps.
  • Convenient set function of cumulative dosage and lamp Off.

 

Specifications
Model TH-ICH-300 TH-ICH-800 
Chamber Volume (L / cu ft) 300 / 10.6 760 / 26.8
Controller PID control (LCD Type)
Temperature 1) Range without Humidity (℃ / oF) -5 to 85 / 23 to 185 without Light
0 to 85 / 32 to 185 with Light
with Humidity (℃ / oF) +15 to 85 / 59 to185 with Light
Fluctuation 1) (±℃ / oF) at 40℃ / 60%RH 0.3 / 0.55 0.3 / 0.55
Variation 1) (±℃ / oF) at 40℃ / 60%RH 0.5 / 0.9 0.7 / 1.3
Humidity Range (%RH) FULL RANGE : 20 to 85
40 to 80 at 15℃ (59oF)
30 to 85 at 30℃ (86oF)
20 to 85 at 50℃ to 85℃ (122oF to 185oF)
Fluctuation 2) (±%RH) at 60%RH / 40℃ 3
Variation 2) (±%RH) at 60%RH / 40℃ 5
Light Source
(ICH Q1B option 2)
Cool White 3) 6,000 lux 6,500 lux
Ultraviolet-A 3) 4.5 W/㎡ 5 W/㎡
Light Uniformity VIS. : ±10% UVA : ±15% VIS. : ±15% UVA : ±15%
Typical Time Required to Reach ICH Recommendation of 1.2 million lux-hr ≒ 200Hr ≒ 184Hr
Typical Time Required to Reach ICH Recommendation of 200 W-hr/m2 ≒ 50Hr ≒ 40Hr
Time Heating 4) 25min (20℃ → 85℃) 30min (20℃ → 85℃)
Cooling 4) 35min (20℃ → -5℃) 40min (20℃ → -5℃)
Refrigeration System Air - cooled
Refrigerant R- 404A
Capacity (W) 250 470
Cooler Copper plate fin cooler
Heater Material Ni-Cr Wire Heater / SUS Tube Heater
Drying Bulb (W) 1500 2300
Humidity Bulb (W) 1200 2000
Sensor Temperature Pt 100
Humidity Electronic sensor (Free of drying a wet pack and good response time)
Air Flow 2 set of sirocco fan (2×60 W) : Vertical type
Material Internal SUS #304 (2B polish)
External SUS #304 (Hairline finish) & Steel, 2t, Double painted & baked
Insulation Polyurethane (70mm / 2.76")
Door EPDM Sheet
Operating Temperature 18℃ to 30℃ / 64.4oF to 56oF, 85%RH (Non-corrosive and pure place)
Water Tank Capacity (L / cu ft) 15 / 0.53
Water Quality pH6.2 ~ 7.2, Electrical conductivity 20㎲ / cm to below
Interface Port Basically RS-232C, [RS-485 : optional]
Cable Port Basically one hole provided / Ø 50mm (2"),Optionally max. two holes available / Ø 50 or 80mm (2 or 3.2")
Quantity of Wire Shelves (included / max.) 2 / 8 2 / 17
Distance of between Shelves (mm / inch) 60 /2.4
Dimension
(W×D×H)
Internal (mm / inch) 750×650×650 / 29.5×25.6×25.6 750×880×1160 / 29.5×34.6×45.7
External (mm / inch) 1130×985×1520 / 44.5×38.8×59.8 1220×1215×1965 / 48×47.8×77.4
Net Weight (kg / lbs) 280±10 / 617±22 400±10 / 882±22
Electrical Requirements AC230V, 1ph, 60Hz 15.4 A 24.5 A
Cat.No. AAHC1001K AAHC1011K
AC230V, 1ph, 50Hz 14.7 A 23.5 A
Cat.No. AAHC1002K AAHC1012K

1) All specifications are under ambient temperature 20℃ (68oF), No load.
2) Technical data according to DIN 12880, IEC 60068.
3) The value is measured on the center of chamber at the point of vertical direction.
4) Up to 98% of the set value.

 

Accessories & Options
Viewing Window
  • An observation window is only installed in the floor type chambers.
Inner Door
  • An inner glass door comes installed with the clean temperature & humidity chamber for quick viewing of samples and to prevent outside air from flowing in. (Table top - without hand entry ports.)
Temperature and Humidity Recorder
  • 6-point dot type recorder.
  • Digital display.
Water Supply
  • Water supply system for supplying pure water for humidification.
    • Maintenance of the water tank can be easily performed from the front side.
Cable Port
  • A through hole of 50 or 80mm dia. (2.0 or 3.2˝ dia.) is provided on the wall of chamber to allow electrical cables to be intro-duced into the chamber. A 50mm hole is provided, maximum two holes (50 or 80mm) are optional.
Water Purifier
  • Water purifier with reverse osmosis membrane. (optional)
Shelf
  • Wire and perforated type shelves (shelf brackets included) are made of durable stainless steel. Standard shelves and shelf brackets come standard.
Warning Signal Light
  • A malfunction indicator can be placed on the right upper side.
Floor Standing Chambers
  • □ Included ○ Optional
Cat. No. Description TH-TG TH-ICH TH-CR
AAA8T500 Recorder (6 points)
AAA8T505 Recorder (Digital, 6 channels)
AAA8T541 Interface Converter RS-485C -> 232C Included a Cable (5m / 16.4ft)
AAA8T542 Interface Cable (5m / 16.4ft)
AAA80550 Warning Signal Lamp
AAA81552 Inner Glass Door for TH-G / I / KH-180 - - -
AAA81551 Inner Glass Door for TH-G / I / KH-300, 408, CR-270 - - -
AAA81550 Inner Glass Door for TH-G -800, 1000 - - -
AAAC2501 Inner Glass Door for TH-TG-180 - -
AAAC2502 Inner Glass Door for TH-TG-300, 408 - -
AAAC2503 Inner Glass Door for TH-TG-800, 1000 - -
AAA81554 Inner Glass Door for TH-ICH-300 - -
AAA81555 Inner Glass Door for TH-ICH-800 - -
EDA8212 Wire Shelf for TH - G / I / KH- 180 - - -
EDA8213 Wire Shelf for TH - G/ I / KH - 300  - - -
EDA8214 Wire Shelf for TH - G / I / KH- 408  - - -
EDA8215 Wire Shelf for TH - G - 800 - - -
EDA8216 Wire Shelf for TH - G - 1000 - - -
RTD1302 Wire Shelf for TH-TG-180 - -
RTD1303 Wire Shelf for TH-TG -300 - -
RTD1300 Wire Shelf for TH-TG-408 - -
RTD1304 Wire Shelf for TH-TG-800 - -
RTD1301 Wire Shelf for TH-TG-1000 - -
RTD1305 Wire Shelf for TH-G / TG-1500 - -
RTD1196 Wire Shelf for TH-ICH -300 - -
RTD1198 Wire Shelf for TH-ICH -800 - -
STT1040 Wire Shelf for TH-CR-270  - -
AAA80602-1 Perforated Shelf for TH - G / I / KH - 180  - - -
AAA80602-2 Perforated Shelf for TH - G/ I / KH - 300  - - -
AAA80602-3 Perforated Shelf for TH - G / I /KH - 408  - - -
AAA80602-4 Perforated Shelf for TH - G - 800  - - -
AAA80602-5 Perforated Shelf for TH - G - 1000  - - -
AAA80604-11 Perforated Shelf for TH-TG-180 - -
AAA80604-12 Perforated Shelf for TH-TG -300 - -
AAA80604-13 Perforated Shelf for TH-TG-408 - -
AAA80604-14 Perforated Shelf for TH-TG-800 - -
AAA80604-15 Perforated Shelf for TH-TG-1000 - -
AAA80604-2 Perforated Shelf for TH-ICH -300 - -
AAA80604-4 Perforated Shelf for TH-ICH -800 - -
AAA80630-1 Perforated Shelf for TH-CR-270  - -
AAA8T610 Cable Port (Ø 50mm / 2")
AAA8T611 Cable Port (Ø 80mm / 3.2")
AAA8T621 Water Purifier
AAA80622 Water Cartridge Tank -
CFA7113 Humidity Sensor
CFA1185 Temperature Sensor (RTD type) for TH-G/I/KH - - -
CFA1923 Temperature Sensor (RTD type) for TH-TG/ICH/CR
RTD1190 Fluorescent Lamp(Cool White) for TH-ICH-300 - -
RTD1191 Fluorescent Lamp(Cool White) for TH-ICH-800 - -
RTD1188 UVA Lamp for TH-ICH-300 - -
RTD1189 UVA Lamp for TH-ICH-800 - -
AAA80680 THE-680 UV Sensor TH-ICH - -
AAA80681 THE-681 Illumination Sensor for TH-ICH - -
EDA9175 ULPA filter - -
EDA9184 HEPA Filter (1EA included) - -
AAA80620 Direct Water System